电纺压电聚偏二氟乙烯有序纳米纤维及其在压力传感器中的应用

王凌云; 马思远; 吴德志

doi:10.3788/OPE.20162410.2498

您当前的位置：

首页 >

文章列表页 >

电纺压电聚偏二氟乙烯有序纳米纤维及其在压力传感器中的应用

微纳技术与精密机械 | 更新时间：2020-07-07

- 电纺压电聚偏二氟乙烯有序纳米纤维及其在压力传感器中的应用
- Electrospinning of aligned PVDF nanofibers with piezoelectricity and its application in pressure sensors
- 光学精密工程 2016年24卷第10期页码：2498-2504
- 作者机构：
  
  厦门大学机电工程系, 福建厦门 361000
- 作者简介：
  
  王凌云(1978-),男,四川通江人,副教授,2001年、2009年于厦门大学分别获得学士和博士学位,主要从事MEMS和惯性传感器的设计、制作和控制,微纳加工及应用等方面的研究。E-mail:wangly@xmu.edu.cn
  [ "马思远(1995-),女,河南南阳人,2013年就读于厦门大学电气工程及其自动化专业。E-mail:940936803@qq.com" ]
- 基金信息：
  
  国家自然科学基金青年基金资助项目(51105320)
- DOI：10.3788/OPE.20162410.2498
  中图分类号： TP212.12;TQ343
- 收稿日期：2016-05-07，
  
  录用日期：2016-6-10，
  
  纸质出版日期：2016-10
- 稿件说明：
移动端阅览
王凌云, 马思远, 吴德志. 电纺压电聚偏二氟乙烯有序纳米纤维及其在压力传感器中的应用[J]. 光学精密工程, 2016,24(10):2498-2504.

Ling-yun WANG, Si-yuan MA, De-zhi WU. Electrospinning of aligned PVDF nanofibers with piezoelectricity and its application in pressure sensors[J]. Optics and precision engineering, 2016, 24(10): 2498-2504.
王凌云, 马思远, 吴德志. 电纺压电聚偏二氟乙烯有序纳米纤维及其在压力传感器中的应用[J]. 光学精密工程, 2016,24(10):2498-2504. DOI： 10.3788/OPE.20162410.2498.

Ling-yun WANG, Si-yuan MA, De-zhi WU. Electrospinning of aligned PVDF nanofibers with piezoelectricity and its application in pressure sensors[J]. Optics and precision engineering, 2016, 24(10): 2498-2504. DOI： 10.3788/OPE.20162410.2498.

摘要

针对传统静电纺丝法制备聚偏二氟乙烯（PVDF）压电纤维工艺复杂和效率低等问题，提出了采用滚筒收集方式制备PVDF有序纳米纤维的方法。通过改变滚筒转速收集纤维，得到了有序程度不同的PVDF纤维膜。用傅立叶变换红外光谱（FTIR）分析了有序纤维膜β晶相的含量，并利用NI数据采集卡在相同条件下测试了纤维膜的压电特性。结果表明：随着滚筒转速提高，纤维有序度增强，β相的含量提高，压电电压输出也明显增大，由此得知滚筒转速变化对β晶相的含量及压电输出电压的影响规律基本一致。基于得到的结果，设计制作了利用该有序PVDF纤维膜的压力传感器，并在不同气压下进行了动态响应测试。结果显示：所制备的PVDF有序纤维压力传感器在0.145~0.165 MPa下的电压输出随气压的增加呈线性增大，表现出了良好的线性度，其灵敏度达179 mV/kPa。采用该种方法制备PVDF纤维对研制动态压力传感器极有意义。

Abstract

It has complex process and lower efficiency when traditional electrospinning preparation method is used to prepare the poly (vinylidene fluoride) (PVDF) piezoelectric fibers

so this paper proposes a new method for the PVDFs by using a rotation drum to collect aligned PVDF nanofibers. Aligned fiber membranes with different alignment degrees were collected by changing the rotating speed. Then

the Fourier Transform Infrared (FTIR) spectroscopy was used to analyze the content of β phase of the fiber membranes and a data acquisition card of National Instrument (NI) was used to research the piezoelectric property of piezoelectric fiber membrane under the same pressing force. The results show that the order of fiber alignment and the content of β phase are both improved as the rotating speed increasing

and the output voltage of piezoelectric also increases

which indicates that the change of rotating speed has the same influence on the content of β phase and the output voltage. Based on the aligned PVDF fiber membrane

a pressure sensor was designed and its dynamic responses under different air pressures were obtained with a lab-made testing system. In the pressure range of 0.145-0.165 MPa

the piezoelectric output of the sensor increases linearly with the increment of air pressure

showing excellent linearity and high sensitivity up to 179 mV/kPa. The preparing method for PVDF nanofibers has wide application prospects

especially in the field of high accuracy dynamic pressure tests.

关键词

Keywords

references

靳亚静.PVDF动态特性研究与键盘应用设计[D]. 大连:大连理工大学,2009. http://cdmd.cnki.com.cn/article/cdmd-10141-2010021668.htm

JIN Y Y. The Research on PVDF Dynamic Response and Design of Keyboard Application[D]. Dalian:Dalina University of Technology, 2009.(in Chinese)

王奇武,周凤星. 可穿戴式无线脉搏监测系统前端设计[J]. 计算机测量与控制,2014,22(10):3135-3137.

WANG Q W, ZHOU F X. Front-end design of wearable wireless pulse monitoring system[J]. Computer Measurement&Control, 2014, 22(10):3135-3137.(in Chinese)

FANG J, WANG X, LIN T. Electrical power generator from randomly oriented electrospun poly (vinylidene fluoride) nanofibre membranes[J]. Journal of Materials Chemistry, 2011, 30(21):11088-11091.

卢朝洪,梅涛,骆敏舟,等. 一种用于机器人手爪的PVDF接触力传感器设计[J]. 压电与声光,2006,28(3):311-313.

LU CH H, MEI T, LUO M ZH, et al.. A PVDF contact force sensor for robotic hand[J]. Piezoelectectrics & Acoustooptics, 2006, 28(3):311-313.(in Chinese)

郑高峰,王凌云,孙道恒. 基于近场静电纺丝的微纳米结构直写技术[J]. 光学精密工程,2008,16(1):20-24.

ZHENG G F, WANG L Y, SUN D H. Micro nano-structure direct-write technology basedon near-field electrospinning[J]. Opt. Precision Eng., 2008, 16(1):20-24.(in Chinese)

于永泽,刘媛媛,陈伟华,等. 溶剂挥发对静电纺丝纳米纤维支架直径与沉积的影响[J]. 光学精密工程,2014,22(2):420-425.

YU Y Z, LIU Y Y, CHEN W H, et al.. Effect of solvent evaporation on diameter and deposition of nanofibrous scaffold in electrospinning[J]. Opt. Precision Eng., 2014,22(2):420-425.(in Chinese)

DOSHI J,RENEKER D. Electrospinning process and applications of electrosponfibs[J]. Journal of Electrostatics, 1995, 35(2-3):151-160.

LI D,XIA Y. Electrospinning of nanofibers:Reinventing the wheel[J]. Advanced Materias, 2004, 16(14):1151-1170.

BAE J H, CHANG S H. Characterization of an electroactive polymer (PVDF-TrFE) film-type sensor for health monitoring of composite structures[J]. Composite Structures, 2015, 1(131):1090-1098.

CHIEH C, FUH Y K,LIWEI L. A direct-write piezoelectric PVDF nanogenerator[C]. Solid-State Sensors, Actuators and Microsystems Conference, 2009. TRANSDUCERS 2009. International, 2009, 10:1485-1488.

PU J,YAN X,JING Y. Electrospun aligned fibrous arrays and twisted ropes:Fabrication, mechanical and electrical. properties, and application in strain sensors[J]. Sensors and Actuators, A:Physical, 2010, 10(475):131-136.

MARQUES S M,TAVARES C J, LANCEROS-MENDEZ S, et al.. X-ray scattering experiments on sputtered titanium dioxide coatings onto PVDF polymers for self-cleaning applications[J]. Journal of Applied Polymer Science, 2011, 119(2):726-731.

TASCAN M. Optimization of process parameters of wet-spun solid PVDF fibers for maximizing the tensile strength and applied force at break and minimizing the elongation at break using the Taguchi method[J]. Journal of Engineered Fibers and Fabrics, 2014, 9(1):165-173.

KOLEV G D,ALEKSANDROVA M P,DENISHEV K H.Spray deposition of PVDF layers with application in MEMS pressure sensors[J]. International Journal of Reasoning-based Intelligent Systems, 2013, 5(3):177-182.

BERINGER L T, XU X,SHIH W, et al.. An electrospun PVDF-TrFe fiber sensor platform for biological applications[J]. Sensors and Actuators, A:Physical, 2015, 222(11):293-300.

MA C C,CHUANG K C,PAN S Y. Polyvinylidene fluoride film sensors in collocated feedback structural control:Application for suppressing impact-induced disturbances[J]. IEEE Transactions on Ultrasonics, Ferroelectrics, and Frequency Control, 2011, 58(12):2539-2554.

ZHU H,LU Y,LIU X,et al.. The manufacture and mechanical analysis of the PVDF flexible sensors[J]. Sensors and Transducers, 2013, 158(11):33-40.

徐浩,芮筱亭,冯宾宾,等. 基于PVDF压电薄膜的大口径火炮弹底发射装药挤压应力测试方法[J]. 振动与冲击,2012,31(22):20-23+44.(in Chinese)

XU H,RUI X T,FENG B B, et al.. Measuring method for big area projectile base compression stress of propellant charge based PVDF piezoelectric film[J]. Journal of Vibration and Shock, 2012, 31(22):20-23+44. (in Chinese)

DEZHI W,SHAOHUA H, ZHIMING X, et al.. Piezoelectric properties of PVDF nanofibers via non-uniform field electrospinning.in Manipulation, Manufacturing and Measurement on the Nanoscale (3M-NANO)[C]. International Conference on, 2014, 10:285-289.

王庆锋,吴斌,宋吟蔚,等. PVDF压电传感器信号调理电路的设计[J]. 仪器仪表学报,2006, 27(6):1653-1655.

WANG Q F,WU B, SONG Y W, et al.. Design of signal conditioner circuit for the PVDF piezolectric transducer[J]. Chinese Journal of Scientific Instrument, 2006, 27(6):1653-1655.(in Chinese)

SUK H P, DONG Y Y. Fabrication of aligned electrospun nanofibers by inclined gap method[J]. Journal of Applied Polymer Science, 2010, 120(3):1800-1807.

李文望,郑高峰,王衡,等. 电纺直写纳米纤维在图案化基底的定位沉积[J]. 光学精密工程,2010,18(10):2231-2238.

LI W W, ZHENG G F, WANG X, et al.. Position deposition of electrospinning direct-writing nanofiber on pattern substrate[J]. Opt. Precision Eng., 2010, 18(10):2231-2238.(in Chinese)

SENCADAS V, et al.. α to β phase transformation and microestructural changes of PVDF films induced by uniaxial stretch[J]. Journal of Macromolecular Science, 2009, 48(3):514-525.

DAVIS G, et al.. Electric field induced phase changes in poly (vinylidene fluoride)[J]. Journal of Applied Physics, 1978, 49(10):4998-5002.

浏览量

296

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

同轴激光辅助电纺射流检测

压力传感器波纹膜片低应力激光焊接工艺

磁致伸缩压力传感器设计及其输出特性

电纺氧化锌纳米纤维乙醇、丙酮气敏传感器

溶剂挥发对静电纺丝纳米纤维支架直径与沉积的影响